Aarrow Becton 7 mk3 Manual de Instalação

Aarrow Fires LtdThe FireworksBridportDorset, DT6 3BEGreat BritainTel. (44) 01308 427234Fax. (44) 01308 423441www.aarrowfires.comThe BectonMultifuel St

Step 4 Remove the glass completely. Store glass-retaining clips and white gasket (if sound) safelyfor re-use.Step 5 Follow this procedure in reverse t

FUEL TYPESWood- Any type of wood is suitable provided it iswell seasoned and has a moisture content below20%. This usually implies that the timber ha

ENSURE THAT YOU HAVE READ &UNDERSTOOD THESE INSTRUCTIONSBEFORE LIGHTING THE FIRE.ALWAYS WEAR SUITABLE PROTECTIVEFIRE GLOVES WHEN REFUELLING YOURS

ASH REMOVALThe ash pan should be emptied at least twice a dayor when the level of ash reaches the top of the ashpan. On no account should the ash be a

ANNUAL MAINTENANCEIt is important that your fire is regularly serviced inaccordance with these instructions. This should becarried out at least annua

Becton Multifuel Stoves 15ACCESSORIESACCESSORIESSTANDSElegant stands are available for the Becton free-standing fires. These increase the height of th

16 Becton Multifuel StovesINSTALLATIONGENERAL PRECAUTIONSNote - All installations must conform to theappropriate building regulations. The Building Re

Becton Multifuel Stoves 17INSTALLATIONFIREBOX LINER PANELSThe Becton Multifuel stoves use firebox linerpanels to the base, sides and back. The BectonM

MULTIFUEL GRATEGRATEThe grates in the Becton Multifuel units comprise aseries of reciprocating cast iron bars seated on apivoted "comb". All

Becton Multifuel Stoves 19INSTALLATIONFITTING THE FLUE OUTLET ANDHOT PLATEThe flue outlet spigot is found inside the appliance.The hot plate (blanking

Congratulations on your choice of an Aarrow Stove.More than 20 years experience has been put into the development ofour Becton Family to ensure ultima

Due to the gradual introduction of EuropeanChimney Standards chimneys will be specifiedaccording to their performance designation asdefined in BS EN 1

Becton Multifuel Stoves 21INSTALLATION

22 Becton Multifuel StovesINSTALLATIONPLAN VIEW OF REGISTER PLATE ANDCLEARANCES FOR NON INSULATEDFLUESTYPICAL METAL INSULATED CHIMNEY SYSTEMTO BE INST

Becton Multifuel Stoves 23INSTALLATIONADD IN BOILERSBecton multifuel stoves offer the option of acantilever boiler or a slab boiler, which occupiesthe

24 Becton Multifuel StovesINSTALLATIONPrimary flow and return pipes should be 28mmdiameter. The cylinder should be installed at ahigher level than the

Becton Multifuel Stoves 25INSTALLATIONCHECKLISTHearths, Fireplaces, Flues and chimneysThis checklist is to ensure hearths, fireplaces, flues and chimn

26 Becton Multifuel StovesPARTS LIST1. Fuel RetainersAFS155 AFS152 AFS153 AFS154AFS1018 AFS1019 AFS1020 AFS034AAFS001 AFS001 AFS001 AFS002AFGS064 AFS0

Becton Multifuel Stoves 27PARTS LIST8. Liner SetAFS1015 AFS1016 AFS1017 AFS1045AFS1058 AFS1060 AFS1062 AFS1064AFS1059 AFS1061 AFS1063 AFS1065AFS069 AF

28 Becton Multifuel StovesPARTS LIST15. Fire Door RopeKit Complete withDoor Rope Glue.AFS048 AFS048 AFS048 AFS048AFS018 AFS042 AFS043 AFS044AFS094A AF

GuaranteeOnce again we would like to thank you for buyinga Becton fire. When you buy an Aarrow Fire, you are not onlybuying a first class appliance -

INTRODUCTION PageSafety Notices 5The Principle of the Fire 5Check List 6Technical Data 7OPERATING INSTRUCTIONSFirebox Linings and Throat Plate Rem

Should you have any questions about your Becton Multifuel Stove that is not covered in this manual pleasecontact your Aarrow retailer.Please keep all

Lifetime GuaranteeFor your peace of mindAarrow Fires gives a Lifetime Guarantee against manufacturing defects of the mainbody* of its Becton range of

FINAL FACTORY CHECK LISTBK006AQUALITYFINISHPARTSFLUE OUTLETHOT PLATEFUEL RETAINERSGRATEFIREBOX LININGSTHROAT PLATEAIR WASHDOOR CATCHESINTERLOCKASH PAN

Aarrow Fires LtdThe FireworksBridportDorset, DT6 3BEGreat BritainTel. (44) 01308 427234Fax. (44) 01308 427441www.aarrowfires.comThe Becton MK 3Range o

Congratulations on your choice of an Aarrow Stove.More than 20 years experience has been put into the development ofour Becton Family to ensure ultima

PageINTRODUCTIONSafety Notices 4General Information 4Statutory Requirements 5OPERATING INSTRUCTIONSTechnical Data 6Fire Dimensions 6Fitting the Lining

References in this manual to British Standards andStatutory Regulations and Requirements apply onlyto the United Kingdom. For Ireland the rules inforc

IMPORTANT NOTICESA qualified gas engineer must carry out theinstallation and servicing of this appliance inaccordance with these instructions and inco

6 Becton Bunny & Becton 7 mk3 Gas stovesOPERATING INSTRUCTIONSFIRE DIMENSIONSCategory I2HFor use in GB and IE at a supply pressure of 20mbarTECHNI

FITTING THE LINING PANELSBecton 7 only. The lining panels supplied are to beinstalled into the fire before the coal matrix isfitted. Note: The lining

WARNINGTO ALL MULTIFUEL USERSPETROLEUM COKESOME OF WHOSE BRAND NAMES ARE"CALCO", "PETROCOKE" OR "WONDERCO"MUST NOT BE BU

ARRANGING THE COALSSafety Notice - Please see SAFETY NOTICESref. Coal set page 4.Warning: The coals and the coal matrices arefragile ensure they are h

LIGHTING & CONTROLLINGTHE FIREUnder no circumstance must the fire be operated ifthe glass is cracked or broken.Open the gas control access door si

Fig 5dFig 5eStep 3. To turn the main burner off while keepingthe pilot alight, rotate the operating knob back tothe PILOT position. (Fig 5e)Fig 5fStep

INSTALLING THE FIREYour CORGI qualified gas engineer should installthe fire in accordance with the followingregulations and standards:-The Gas Safety

The Becton gas stove is designed so that the fluecan be fitted to either the top or the rear of theappliance.Fit the flue spigot and blanking plate fo

Fig. 7b.Fig. 7cFIRE LOCATIONThe appliance must not be installed in a room orspace, which contains a bath or shower.This fire is designed for use with

The minimum height from the extreme top surface of the fire to the underside of a shelf or other projectionmade of wood or any other combustible mater

HEARTH REQUIREMENTSTo comply with current Building Regulations thefire must stand on a fireproof hearth, which has anupper fireproof layer of 12mm non

FIRE TESTINGFlame failure device testingStep 1 Ignite the appliance in accordance withpage 9 and run for 60 seconds.Step 2 Turn the appliance off to e

Becton Bunny & Becton 7 mk3 Gas stoves 17INSTALLATION CHECK LISTCHECKLISTHearths, Fireplaces, Flues and chimneysThis checklist is to ensure hearth

Becton Multifuel Stoves 5INTRODUCTIONSAFETYA fireguard conforming to BS 8423: 2002 shouldbe used in the presence of children and old/orinfirm people.

DETAIL OF PILOT ASSEMBLYIt is strongly recommended to leave the pilot onpermanently. This will keep the fire and itscomponents, including the ceramic

Becton Bunny & Becton 7 mk3 Gas stoves 19SERVICINGDOOR TRIMBecton Fire doors are fitted with a brushed steelfinish trim as standard. The trim is s

BURNER ASSEMBLYTo remove the burner assembly proceed asfollows;Ensure the appliance is cold.Step 1 Turn off the gas supply at the gas service cock. St

ANNUAL SERVICETHIS GAS APPLIANCE MUST BE SERVICEDEVERY TWELVE MONTHS BY A QUALIFIEDGAS ENGINEER.See "SAFETY NOTICES" ref coal set page 4.Ens

22 Becton Bunny & Becton 7 mk3 Gas stovesSERVICINGIs the gas supplyturned on?Does the pilotignite?YesDoes the pilot stay alight?YesDoes the mainbu

GENERAL COMPONENTSSpare parts can be obtained by contacting theoriginal supplier of the fire or Aarrow Fires.Fire Body Ancillary Components. Only use

24 Becton Bunny & Becton 7 mk3 Gas stovesNOTES

Becton Bunny & Becton 7 mk3 Gas stoves 25NOTES

26 Becton Bunny & Becton 7 mk3 Gas stovesSPARE PARTS1. Becton 7 mk3Coal Set-AFGS1075AFGS1074-AFGS089 AFGS089AFGS090 AFGS090AFGS091A AFGS091AFGS107

Becton Bunny & Becton 7 mk3 Gas stoves 27SPARE PARTSAFGS1085 AFGS1085AFGS1076 AFGS1077AFGS080 AFGS080AFS094A AFS095AFGS1078AFGS1079AFGS1080AFGS108

Inside the appliance you should find the following:6 Becton Multifuel StovesCHECK LIST1. Grate Bars5 5 7 9Part Description&Visual Aid(not to scale

28 Becton Bunny & Becton 7 MK3 Gas stovesSPARE PARTS- AFGS1072AFGS093 AFGS09315. Becton 7 mk3Lining Kit16. Large CeramicPanelPart DescriptionVisua

GUARANTEE Once again we would like to thank you for buyinga Becton fire. When you buy an Aarrow Fire, you are not onlybuying a first class appliance -

Should you have any questions about your Becton Gas Stove that is not covered in this manual please con-tact your Aarrow retailer.Please keep all repa

Lifetime GuaranteeFor your peace of mindAarrow Fires gives a Lifetime Guarantee against manufacturing defects of the mainbody* of its Becton range of

FINAL FACTORY CHECK LISTBK027Model...Serial No...I’ve checked itand it’s O.K.Assembled by...

Aarrow Fires LtdThe FireworksBridportDorsetDT6 3BEGreat BritainTel. (44) 01308 427234Fax. (44) 01308 423441www.aarrowfires.comBecton Electric StoveOpe

Congratulations on your choice of an Aarrow Stove.More than 20 years experience has been put into the development ofour Becton Family to ensure ultima

INSTALLATIONWARNING - THIS APPLIANCE MUST NOTBE USED IN A BATHROOM.WARNING - DO NOT USE THIS HEATERIN THE IMMEDIATE SURROUNDINGS OFA BATH, A SHOWER OR

USING THE HEATERSwitching on your heater• Ensure before connecting to the mains, that all the switches are in the OFF position.Located on the right ha

Becton Electric Stove 5GUARANTEEYour Becton Electric stove carries a guarantee against defects of manufacture and faultyworkmanship for a period of on

Becton Multifuel Stoves 7TECHNICAL DATARoom Min/MaxRoom Heater Only Output (kW) 1-5 1.5-7 2-11 3-18TECHNICAL DATA BectonBunnyBecton 7 Becton 11 Becton

This appliance conforms to: European Community standard EN60335-2-30:1997Low Voltage Directive 73/23/EECElectromagnetic Compatibility Directive 89/336

FIREBOX LININGS & THROATPLATEThe Becton Multifuel stoves firebox has reflectiveliners to the sides and rear) and a specially shapedthroat plate

INTERLOCK SYSTEMBecton fires are fitted with an "interlock" system.A situation where the fire door is closed and the ashdoor is open may lea